THE INFLUENCE OF THE PRE-ORGANIZED CRACKS IN THE TENSILE ZONE OF THE REINFORCED CONCRETE BEAM UNDER STATICALLY SHORT-TERM LOADING
https://doi.org/10.26518/2071-7296-2017-6(58)-132-139
Abstract
The experimental and theoretical research of the single-span reinforced concrete beam with artificial flaw in tension area under the action of static short-term loads is performed. The stress-strain state of the structure, based on numerical simulation using finite element software system ANSYS, is investigated. The results of numerical simulation are compared with the experimental results. It is shown that under static short-term loads, the beams with pre-cracking have the crack formation of significantly different nature in comparison with the beams without pre-cracking. The comparative analysis of the experimental data of the reinforced concrete beam under short-term loading with the results of ANSYS Software program modeling is carried out in the article. The introduction of the artificial defects to the tension area of beams would lead to the significant change in the stress- strain state of the structure and to «mild» nature of its deformation. The result of such beams deflections under the load is less than deflections of beams without artificial flaws. The recommendations on the beams’ designing with artificial flaws are given in the article. The results of the modeling cracks’ feasibility in the manufacturing process are demonstrated in the research, because there are the possibilities to regulate the stress fields.
About the Authors
A. Chhom
FGBOU VO «Novosibirsk State University of Architecture and Civil Engineering (Sibstrin)»
Russian Federation
Russian Federation
Post-graduate student of the Department of Reinforced Concrete Structures
630008, Novosibirsk, Leningradskaya St., 113
A. M. Kurobanov
FGBOU VO «Novosibirsk State University of Architecture and Civil Engineering (Sibstrin)»
Russian Federation
Russian Federation
Post-graduate student of the Department of Reinforced Concrete Structures
630008, Novosibirsk-8, Leningradskaya St., 113
F. K. Sametov
FGBOU VO «Novosibirsk State University of Architecture and Civil Engineering (Sibstrin)»
Russian Federation
Russian Federation
Post-graduate student of the Department of Reinforced Concrete Structures
630008, Novosibirsk-8, Leningradskaya St., 113
References
1. Hua Zhu. Crack formation of steel reinforced concrete structure under stress in construction period. Frattura ed Integrità Strutturale, 36 (2016), pp. 191-200.
2. Zheng, S., Su, Y., Zhang, W., Li, Q., Experimental study on seismic performance of joints in the castellated portal frame of light-weight steel, Building Structure, 44(12) (2014), pp. 80-84.
3. Zhao, K., Zhu, Z., Experimental study on behavior of the channel - masonry - concrete composite structures,Applied Mechanics & Materials, 578-579 (2014). Pp. 1251-1256.
4. Goel, M. D., Deformation, energy absorption and crushing behavior of single, double and multi-wall foam filled square and circular tubes, Thin-Walled Structures, 90 (2015), pp. 1-11.
5. Oh, H. K., Park, S. M., Hong, S. I., Hot Deformation and Cracking during Compression of 21-4N Steel, Advanced Materials Research, 1102 (2015), pp. 12-21. Kocsis, P., Discussion of «Simplified Method of Lateral Distribution of Live Load Moment», Journal of Bridge Engineering, 10(5) (2015), pp. 630-631.
6. Gzyl, M., Pesci, R., Rosochowski, A., Boczkal, S., Olejnik, L., In situ analysis of the influence of twinning on the strain hardening rate and fracture mechanism in AZ31B magnesium alloy, Journal of Materials Science, 50(6) (2015), pp. 2532-2543.
7. Fisker J. Shear capacity of reinforced concrete beams without shear reinforcement. PhD thesis. Aarhus (Denmark): Aarhus University; 2014, pp.155.
8. Karpenko N.I., Karpenko S.N. O postroenii bolee sovershennoj modeli deformirovanii zhelezo-betona s treshhinami pri ploskom naprjazhennom sostojanii [On the construction of a more perfect model of reinforced concrete with cracks deformation under plane stress]. II Vserossijskaja (Mezhdunarodnaja) konferencija po betonu i zhelezobetonu. Beton i zhelezobeton – puti razvitiya [Concrete and reinforced concrete are the ways of development]. Moscow, 2005. pp.431 – 444.
9. Karpenko N.I., Karpenko S.N. K postroeniju fizicheskih sootnoshenij v inkremental’noj forme dlja rascheta zhelezobetonnyh konstrukcij s treshhinami [To the construction of physical relationships in incremental form for the calculation of reinforced concrete structures with cracks]. pervaya Vserossijskaya konferenciya po problemam betona i zhelezobetona. Beton na rubezhe tret’ego tysyacheletiya [Concrete at the turn of the third millennium]. Moscow, vol. 2, 2001. pp. 711 – 717.
10. Mitasov V.M. Opredelenie naprjazhenij armatury zhelezobetonnogo jelementa v sechenie s treshhinoj. Izvestija vuzov [Determination of reinforcement stresses of a reinforced concrete element in a section with a crack], Izvestija vuzov, 1988, no 3, pp. 116 – 118.
11. Mitasov V.M., Adishchev V.V. Osnovnye predposylki postroenija jenergeticheskoj teorii soprotiv-lenija zhelezobetona [The basic preconditions for building the energy theory of resistance of reinforced concrete]. Izvestija vuzov, 2010, no 5, pp. 3 – 9.
12. Mitasov V.M., Adishchev V.V. Osnovnye polozhenija jenergeticheskoj teorii soprotivlenija zhelezo-beton [Basic provisions of the energy theory of resistance of reinforced concrete]. Izvestiya vuzov, 2010, no 6, pp. 3 – 8.
13. Mihajlova N.S. Jeksperimental’nye issledovanija zhelezobetonnyh balok bez treshhin i zaranee namechennoj treshhiny [Experimental studies of reinforced concrete beams without cracks and a predetermined crack] Izvestija vuzov, 2007, no 4, pp. 110 – 113.
14. Logunova M.A., Peshkov A.S. Jeksperimental’nye issledovanija betonnyh balok bez organizovan-nyh treshhin i s zaranee organizovannymi treshhinami [Experimental studies of concrete beams without organized cracks and with prearranged cracks] Izvestija vuzov, 2011, no 1, pp.116 – 120.
15. Mihajlova N.S., Mitasov V.M. Naprjazhennodeformirovannoe sostojanie zhelezobetonnoj balki s treshhinoj [Stress-strain state of a reinforced concrete beam with a crack]. Materialy Mezhdunarodnyh akademicheskih chtenij. Kursk. 2007. pp.104 – 108.
16. Albaut G.N., Mitasov V.М., Pichkurova N.S., Tabanjuhova M.V. Model’noe issledovanie vlijanija organizovannyh treshhin na naprjazhennoe sostojanie balok [Pichkurova N.S., Tabanjuhova M.V. Model of investigation of the effect of pre- organized cracks on the stressed state of beams]. Izvestija vuzov, 2009, no 6, pp.119 – 127.
17. Bruyaka V.A., Fokin V.G., Soldukova E.A., Adeanov I.E. Inzhenernyj analiz v ANSYS Workbench [Engineering analysis in ANSYS Workbench]. Samara, Samr., Samr.gosud. tekhn.un-t, 2010, 271 p.
18. Samul V.I. Osnovy teorii uprugosti i plastichnosti [Fundamentals of the theory of elasticity and plasticity]. Мoscow, Vysshaja shkola, 1982. 264 p.
19. Geniev G.A., Kissyuk V.N., Teorija plastichnosti betona i zhelezobetona [Tyupin G.A. Theory of plasticity of concrete and reinforced concrete]. Moscow, Strojizdat, 1974. 316 p.
20. Klovanich S.F., Mironenko I.N. Metod konechnyh jelementov v mehanike zhelezobetona [The finite element method in the mechanics of reinforced concrete]. Odessa, 2007. 110 p.
21. Adishchev V.V., Demeshkin A.G., Shulga V.K., Gracheva M.S., Danilov M.N., Maltsev V.V. Opredelenie zony ankerovki armirujushhego jelementa pri vytjagivanii iz matricy betona [Determination of the anchoring zone of the reinforcing element when drawing from the matrix of concrete]. Izvestija vuzov, 2014, no 12, pp. 67 – 79.
Review
For citations:
Chhom A., Kurobanov A.M., Sametov F.K. THE INFLUENCE OF THE PRE-ORGANIZED CRACKS IN THE TENSILE ZONE OF THE REINFORCED CONCRETE BEAM UNDER STATICALLY SHORT-TERM LOADING. The Russian Automobile and Highway Industry Journal. 2017;(6(58)):132-139. (In Russ.) https://doi.org/10.26518/2071-7296-2017-6(58)-132-139
Views:
765
Email this article 