EXPERIMENTAL RESEARCH OF THE FRIABLE LOAD OFFSETS’ EFFECT ON THE VEHICLES’ AXIAL CARGO CHANGING
https://doi.org/10.26518/2071-7296-2019-2-156-165
Abstract
Introduction. Law changes concerning road service and cargo traffic rules lead to the necessity of maximal axel load calculating during the cargo transportation. Such problem is particularly important while friable cargo transporting, as accelerating or breaking cargoes (road-trains) at a longitude inclination or turning could provoke partial lading shift towards the cargo axles. The paper demonstrates the results of friable cargo offset experimental research (grail, broken stone) while transporting. Moreover, the authors also describe influence of the friable cargo offsets on freight transport axle load changing.
Materials and methods. The research measured friable cargo level in the road-train semitrailer before and after the experiment, axle weighting and the full mass weighting. In addition, the authors made video filming of friable cargo offsets.
Results. Analyzing the experimental data of axial weighting, the authors noted that during the friable cargo transportation, the cargo was redistributed inside the semitrailer and such process led to a change in axial loads of the road-train. The axel load changing was not included into the measurement accuracy and was about 1,4 – 4,9%. Another argument of the friable cargo shift inside the semitrailer was cargo video filming while transporting. Video analysis showed that both chip stone and gravel was moving inside the semitrailer while the road-train accelerated motion.
Discussion and conclusions. As a result, the research proves the experimental verification of the friable cargo offset over the semitrailer ramps while braking. Such offsets lead to the changing of freight transport axle load.
About the Authors
E. R. Kirkolup
Altai State Technical University named after I.I. Polzunov
Russian Federation
Russian Federation
Kirkolup Evgenij Romanovich – Candidate of Technical Sciences, Senior Lecturer of the Building Structure Department
656038, Barnaul, 46 Lenin Ave.
I. V. Kharlamov
Altai State Technical University named after I.I. Polzunov
Russian Federation
Russian Federation
Kharlamov Ivan Vikentevich – Candidate of Technical Sciences, Professor of the Building Structure Department
656038, Barnaul, 46 Lenin Ave.
References
1. Kirkolup E.R., KHarlamov I.V., SHajduk А.M. Otsenka vliyaniya smeshhenij sypuchikh materialov na izmenenie osevykh nagruzok, voznikayushhikh pri kinematicheskom vozdejstvii v protsesse gruzoperevozok [Assessment of the shifts impact of bulks on change of the axial loads arising at kinematic influence in the course of cargo transportation]. Polzunovskij al’manakh, 2018, no 1, pp. 101−108 (in Russian).
2. Аbdyushev А.А., YUmanov V.А. Opredelenie nagruzok na transportnoe sredstvo ot dinamicheskogo vozdejstviya gruzov pri ehkstrennom tormozhenii [Definition of vehicle loads of the from dynamic influence of freights at emergency brake application]. Izvestiya Kazanskogo gosudarstvennogo arkhitekturno-stroitel’nogo universiteta, 2012, no 2 (20), pp. 280−288 (in Russian).
3. Taghavifar H., Mardani A. Off-roa vehicle dynamics. Springer. 2017. 183 p. DOI 10.1007/978-3-319-42520-7.
4. Sun Lu. An overview of a unified theory of dynamics of vehicle-pavement interaction under moving and stochastic load // Journal of Modern Transportation. 2013. Vol. 21. No. 3. P. 135-162 DOI 10.1007/s40534-013-0017-8.
5. Jin Yanfei, Luo Xuan. Stochastic optimal active control of a half-car nonlinear suspension under random road excitation // Nonlinear Dynamics. 2013. Vol. 72. No. 1. pp. 185−195 DOI 10.1007/s11071-012-0702-x.
6. Gridnev S.YU., Budkovoj А.N. Otsenka dinamicheskogo vozdejstviya avtomobilya na put’ pri tormozhenii i razgone s uchetom kinematicheskogo vozmushheniya [Assessment of dynamic influence of the car on the way during the braking and dispersal, taking into account kinematic indignation]. Izvestiya Kazanskogo gosudarstvennogo arkhitekturno-stroitel’nogo universiteta, 2012, no 4, pp. 409−415 (in Russian).
7. Mazur V.V. Matematicheskaya model’ dinamiki mass avtotranspornogo sredstva s povrezhdyonnoj pnevmaticheskoj shinoj pri tormozhenii na nerovnoj doroge [Mathematical model of the car dynamics while braking on the uneven road]. Sistemy. Metody. Tekhnologii, 2009, no 2 (2), pp. 36−38 (in Russian).
8. Mazur V.V. Matematicheskaya model’ dinamiki avtomobilya pri tormozhenii na nerovnoj doroge [Mathematical model of the car power balance at movement along the road with uneven microcross-section]. Sistemy. Metody. Tekhnologii, 2009, no 4, pp. 42−45 (in Russian).
9. Mazur V.V. Matematicheskaya model’ silovogo balansa avtomobilya pri dvizhenii po doroge s nerovnym mikroprofilem [Mathematical model of power balance of the car power balance at movement along the road with uneven microcross-section]. Sistemy. Metody. Tekhnologii, 2009, no 3, pp. 29−32 (in Russian).
10. Sharp R.S., Crolla D.A. Road vehicle suspension system design – a review // International Journal of Vehicle Mechanics and Mobility. 1987. V. 16. No. 3. pp. 167−192. DOI 10.1080/00423118708968877.
11. Kadisov G.M., CHernyshov V.V. Konechno-ehlementnoe modelirovanie dinamiki mostov pri vozdejstvii podvizhnoj nagruzki [Final and element modeling of the bridges’ dynamics at influence of the mobile loading]. Inzhenerno-stroitel’nyj zhurnal, 2013, no 9 (44), pp. 56−63 (in Russian).
12. Gridnev S.YU., Budkovoj А.N. Modelirovanie sovmestnykh kolebanij proletnykh stroenij i avtotsistern s chastichno napolnennymi zhidkost’yu kuzovami pri perekhodnykh rezhimakh dvizheniya [Modeling of joint fluctuations of flying buildings and tanker trucks with the bodies which are partially filled with liquid at transient states of the movement]. Nauchnyj vestnik Voronezhskogo gosudarstvennogo arkhitekturno-stroitel’nogo universiteta. Stroitel’stvo i arkhitektura, 2009, no 3 (15), pp. 103−110 (in Russian).
13. Gridnev S.YU., Budkovoj А.N. Ispol’zovanie mekhanicheskogo analoga zhidkosti dlya modelirovaniya kolebanij avtotsisterny pri razgone i tormozhenii [Use of a mechanical flu id analogue for modeling tank truck oscillations during acceleration and deceleration]. Nauchnyj zhurnal stroitel’stva i arkhitektury, 2011, no 1, pp. 98−106.
14. Shvets A.O. Influence of the longitudinal and transverse displacement of the cargo gravity center in gondola cars on their dynamic indicators. Nauka ta progres transport, 2018, no 5 (77), pp. 115−128.
15. Putyato А.V., Sokolovskij А.I. Nagruzhennost’ tortsevoj steny poluvagona pri izmenenii kogezionnykh svojstv sypuchego gruza [Loading of semi track at change of cohesive properties of loose freight]. Аktual›nye voprosy mashinovedeniya, 2016, Vol. 5, pp. 191−194 (in Russian).
16. Putyato А.V., Belogub V.V. Metody modelirovaniya i raschetnye skhemy nagruzhennosti kuzovov vagonov pri perevozke sypuchikh gruzov [Methods of modeling and settlement schemes of loading of cars in transit loose freights]. Mekhanika. Nauchnye issledovaniya i uchebno-metodicheskie razrabotki, 2007, no 1, pp. 45−53 (in Russian).
17. Bukharitsin P.I., Bezzubikov L.G. Ustrojstvo dlya predotvrashheniya smeshheniya gruzov v tryume i sokhraneniya plavuchesti sudna [Device for prevention of freights’ shift in a hold and maintaining buoyancy of the vessel]. Sovremennye naukoemkie tekhnologii, 2014, no 3, pp. 179−180 (in Russian).
18. Malikova T.E. Primenenie teorii katastrof dlya klassifikatsii stsenariev poteri ostojchivosti sudna pri smeshhenii gruza [Application of the accidents’ theory for classification of the scenarios for stability loss of the vessel at freight shift]. Vestnik gosudarstvennogo universiteta morskogo i rechnogo flota im. admirala S.O. Makarova, 2014, no 3 (25), pp. 15-−19 (in Russian).
19. K. Jeon, Y. Yoo, J. Lee, D. Jung Laboratory Alignment Procedure for Improving Reproducibility of Tyre Wet Grip Measurement // International Journal of Automotive Technology. 2016. Vol. 17. No. 3. pp. 457−463. DOI 10.1007/ s12239−016−0047−4.
20. Regulation (EC) No 1222/2009 of the European Parliament and of the Council of 25 November 2009 on the labelling of tyres with respect to fuel efficiency and other essential parameter
Review
For citations:
Kirkolup E.R., Kharlamov I.V. EXPERIMENTAL RESEARCH OF THE FRIABLE LOAD OFFSETS’ EFFECT ON THE VEHICLES’ AXIAL CARGO CHANGING. The Russian Automobile and Highway Industry Journal. 2019;16(2):156-165. (In Russ.) https://doi.org/10.26518/2071-7296-2019-2-156-165
Views:
554
Email this article 