SIMULATION OF THE CONTACT PROCESS INTERACTIONS OF LAND-MOVING AND EARTH-TRANSPORT MACHINES’ WORKING BODIES WITH FROZEN SOIL
https://doi.org/10.26518/2071-7296-2018-2-189-198
Abstract
Introduction. The process of developing frozen soils is considered by the working equipment of earthmoving and earth-moving machinery as a research object. The main aspects of the developed mathematical model and the original method for studying the processes of spatial interaction of the excavating machines’ working bodies with frozen soil are presented. Moreover, such aspects allow to obtain the stress distribution diagrams over the surface of the working body. The nonlinear character of the stresses’ distribution on the contact surface of the working body during the interaction with the soil has been substantiated and proved.
Materials and methods. The description and analysis of the experimental results on the coefficients’ quantitative determination, which enter into the mathematical model, and also the boundaries’ establishment of their adequacy are given. The dependencies have been established to determine the experimental coefficients analytically
Results. The investigations and analysis of the results have been carried out to establish an approximating interrelation between the strength of the frozen soil development and the contact spot on the aluminum plate. Therefore, each abscissa value (the gravity center coordinates of the aluminum plate) and the values of the total normal force are quantified. As a result, good convergence of theoretically obtained dependences with experimental results is shown.
Discussion and conclusion. The carried out researches are the basis for the justifying and determining methodology for the working equipment’s optimal parameters of earth-moving machines with increased efficiency by reducing the energy intensity of the developing frozen soils’ process.
About the Authors
V. N. Kuznetsova
“SibADI”
Russian Federation
Russian Federation
Doctor of Technical Sciences, Professor of the Department “Operation and Service of Transport and Technological Machines and Systems in Construction”,
644080, Omsk, Russia, 5 Mira Ave.
I. S. Kuznetsov
“SibADI”
Russian Federation
Russian Federation
student of the faculty “Oil-and-gas and Building Technology”,
644080, Omsk, Russia, 5 Mira Ave.References
1. Vyalov S.S. Reologiya merzlyih gruntov [Rheology of frozen soils]. Moscow, Stroiizdat, 2000. 464 p.
2. Baker D. G., Ruschy D. L. Calculated and Measured Air and Soil Freeze-Thaw Frequencies. American Meteorological Sociaty, 1995, v 34. no. 10, pp. 2197-2205.
3. Atkinson J. The Mechanics of Soils and Foundations. CRC Press, 2007. 448 p.
4. Tsytovich N.A. Mekhanika merzlyh gruntov: obshchaya i prikladnaya [Mechanics of frozen soils: general and applied]. Moscow, Building, 2013. 448 p.
5. Ershov E.D. Laboratornye metody issledovaniya merzlyh porod [Laboratory methods for studying frozen rocks]. Moscow, Publishing House of Moscow State University, 1985. 146 p.
6. Zhu Y. Constitutive Relations of Frozen Soil in Uniaxial Compression. Journal of Glaciology and Geocryology, 1992, no. 3, pp. 216-220.
7. Roman L.D. Mekhanika merzlyh gruntov [Mechanics of frozen soils]. Moscow, Nauka-Interperiodica, 2002. 426 p.
8. Li Q. Development of Frozen Soil Model. Advances in Earth Science, 2006, no. 12, pp. 96-103.
9. Sun X. ACT-timely experimental study on meso-scopic structural damage development of frozen soil under triaxial shearin. Rock and Soil Mechanics, 2005, no. 8, pp. 150-163.
10. Balovnev V.I. Modelirovanie i prognozirovanie processov vzaimodejstviya mashin s mnogofaznymi sredami: vzaimodejstvie rabochih organov stroitel’nyh, dorozhnyh i kommunal’nyh mashin s gruntom i drugimi materialami [Modeling and forecasting of processes of interaction of machines with multiphase media: interaction of working bodies of construction, road and municipal machines with soil and other materials]. Moscow, MADI, 2000. 61 p.
11. Balovnev V.I., Nguyen Z. Sh. Opredelenie soprotivlenij pri razrabotke gruntov ryhlitelem po integral’nomu pokazatelyu prochnosti [Determination of resistance in the development of soils by a ripper with an integral index of strength]. Construction and road machines, 2005, no. 3, pp. 38-40.
12. Winds Yu. A. Rezanie gruntov zemlerojnymi mashinami [Soil cutting with digging machines]. Moscow, Mechanical Engineering, 1971. 357 p.
13. Zhelukevich R. B. Razrabotka merzlyh gruntov zemlerojnymi mashinami s diskovym instrumentom [Development of frozen soils with digging machines with a disk tool]. Krasnoyarsk, SFU, 2012. 194 p.
14. D’yakov I.F., Ivkin V.S., Zhukova D.V. Nekotorye teoreticheskie osnovy razrusheniya grunta gazoimpul’snym ryhlitelem [Some theoretical bases of soil destruction by a gas-impulse ripper]. Vestnik SSTU, 2013, Volume 2, no. 2c (71), pp. 242-245.
15. Talalay P. G. Subglacial till and bedrock drilling. Cold Regions Science and Technology, 2013, vol 86, pp. 142-166.
16. Leschiner V.B. Sovershenstvovanie instrumenta dlya rezaniya merzlyh gruntov [Perfection of a tool for cutting frozen soils]. Tomsk, Publishing house of Tomsk University, 1991. 210 p.
17. Evdokimov A.N., Vasilyev S.I., Zhubrin V.G. Analiticheskoe opredelenie sily soprotivleniya vnedreniyu instrumenta v merzlyj grunt [Analytical definit on of the force of resistance to the introduction of tools into the frozen ground]. Sistemy. Methods. Technologies, 2011, no. 11, pp. 115-118.
18. Zavyalov A.M., Zavyalov M.A., Kuznetsova V.N. Vzaimodejstvie dorozhnyh i stroitel’nyh mashin s kontaktnoj sredoj [Interaction of road and construction machines with a contact medium]. Omsk, CAS, 2011. 370 p.
19. Martyuchenko I.G. Mashiny i oborudovanie dlya razrabotki i bureniya merzlyh gruntov [Machines and equipment for the development and drilling of frozen soils]. Saratov, Sarat. state. tech. University, 2009. 101 p.
20. Rastegaev I.K. Mekhanika i teplofizika statisticheskogo ryhleniya vechnomerzlyh gruntov [Mechanics and Thermophysics of Statistical Loosening of Permafrost Soils]. Krasnoyarsk, Publishing House of the Krasnoyarsk University, 1988. 222 p. 21. Volkov D.P. Mashiny dlya zemlyanyh rabot [Machines for excavation]. Moscow, Mechanical Engineering, 1992. 448 p.
21. Liu X., Liu P. Experimental research on the compressive fracture toughness of the wing fracture of the frozen soil. Cold Regions Science and Technology, 2011, vol. 65, pp. 421- 428.
22. Ryabets N., Kirzhner F. Weakening of frozen soils by means of ultra-high frequency energy. Cold Regions Science and Technology, 2003, vol. 36, pp. 115-128.
23. Rukovodstvo po opredeleniyu fizicheskih, teplofizicheskih i mekhanicheskih harakteristik merzlyh gruntov [Manual on the determination of physical, thermophysical and mechanical characteristics of frozen soils]. Moscow, Stroiizdat, 1973. 194 p.
24. Vasiliev S.I. Veroyatnostnye fiziko-mekhanicheskie harakteristiki gruntov Vostochno-Sibirskogo regiona [Probabilistic physical and mechanical characteristics of soils of the East Siberian region]. Transport construction, 2013, no. 3 (19), pp. 28-30.
25. Nedorezov I.A. Variacii prochnosti gruntov, razrabatyvaemyh v stroitel’stve [Variations in the strength of soils developed in construction]. Transport construction, 2013, no. 8, pp. 29-30.
26. Kuznetsova V.N. Razvitie nauchnyh osnov vzaimodejstviya kontaktnoj poverhnosti rabochih organov zemlerojnyh mashin s merzlymi gruntami [Development of scientific bases of interaction of a contact surface of working bodies of digging machines with frozen soils]. dis Dr. tehn. sciences. Omsk, 2009. 259 p.
27. Zavyalov A.M., Zavyalov M.A., Kuznetsova V.N., Meshcheryakov V.A. Matematicheskoe modelirovanie rabochih processov dorozhnyh i stroitel’nyh mashin: imitacionnye i adaptivnye modeli [Mathematical modeling of working processes of road and building machines: simulation and adaptive models]. Omsk, SibADI, 2012. 411 p.
28. Rakhmatullin H.A., Sagomonyan A.Ya., Alekseev N.A. Voprosy dinamiki gruntov [Questions of the dynamics of soils]. Moscow, Moscow State University, 1964. 124 p.
29. Zelenin A.N., Balovnev V.I., Kerov I.P. Mashiny dlya zemlyanyh rabot [Machines for excavation works]. Moscow, Mechanical Engineering, 1975. 420 p.
30. Sokolovsky V.V. Statika sypuchej sredy [Static of the granular medium]. Moscow, Fizmatgiz, 1960. 214 p
Review
For citations:
Kuznetsova V.N., Kuznetsov I.S. SIMULATION OF THE CONTACT PROCESS INTERACTIONS OF LAND-MOVING AND EARTH-TRANSPORT MACHINES’ WORKING BODIES WITH FROZEN SOIL. The Russian Automobile and Highway Industry Journal. 2018;15(2):189-198. (In Russ.) https://doi.org/10.26518/2071-7296-2018-2-189-198
Views:
923
Email this article 